Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Explorer / Explorer Sport (U152; 2000, 2001, 2002, 2003, 2004, 2005).

You are watching: 2000 ford explorer xlt fuse box diagram


Checking and Replacing Fuses

Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.

To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.


Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.Always disconnect the battery before servicing high current fuses.Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.If a fuse blows again contact a qualified service center.

Passenger Compartment Fuse Box

The fuse panel is located below the instrument panel on the driver’s side.



№ACircuits Protected
130Memory seat module, Driver power seat (2003-2005), Driver power lumbar (2005)
220Heated seats (2001-2002), Moonroof
320Radio, Amplifier, Power antenna (2001-2002), DVD
45Front wiper module
515Flasher relay (Turn, hazards)
610Right horn (2001-2002), Key-in-chime (2003-2005)
715Heated mirrors
85Heated PCV (2004-2005; 4.0L engine only)
9Not used (spare)
1010Heated backlight relay coil, Heated seat module (2001-2002), Temp blend actuator (2001-2002), A/C clutch contact
1120Heated seats (2003-2005)
125Foglamp switch (2001-2002), 4x4 module
135Overdrive cancel switch, Flex fuel sender (2001-2003)
145PATS module
155Rear wiper module, Cluster, TPMS (2001-2003)
165Power mirror, Manual climate control, TPMS
1715Delayed acc. coil, Battery saver, Interior lamps (front and rear), Glove compartment lamp
1810Left horn (2001-2003), Flexible fuel pump (2004-2005)
1910RCM, PAD indicator (2001-2002)
205Memory driver seat switch, Driver seat module, Body Security Module (BSM), PATS LED, Sunload sensor (2001-2003)
215Instrument cluster, Compass, Flasher coil
2210ABS, IVD Controller
23152001-2003:Brake pedal position switch, Driver brake applied relay, Redundant cruise deactivate switch
2415Cigar lighter, OBD II, Neutral tow
255Mode-Temperature actuator for auxiliary climate control, Trailer tow battery charge coil, TPMS (2004-2005)
267.5Reverse park aid, Brake shift interlock, Approach lamp relay coil (2001-2002), IVD switch
277.5Automatic dimming mirror, Digital transmission range sensor, Backup lamps
285Radio (Start)/DVD (Start)
2910Digital transmission range sensor, PWR feed to fuse #28 (Start feed)
305Daytime Running Lamps (DRL), Remote solenoid, DEATC climate controller, Manual climate control, Manual climate control temp blend actuator
Top side

These relays are located on the reverse side of the passenger compartment fuse panel.


№Circuits Protected
1Flasher relay
2Rear defrost
3Delayed accessory relay
5Battery saver

Engine Compartment Fuse Box

The power distribution box is located in the engine compartment.



№ACircuits Protected
320GCC pusher fan (2001-2002; export only)
430Rear defrost
540Anti-lock Brake System (ABS) pump
660Delayed accessory, Power windows (2004-2005), Audio (2004-2005)
720Power point #2
8304x4 shift motor (2004-2005)
920Power point #1
1030ABS module (valves)
1140PTEC (2001-2003), Powertrain Control Module (PCM) (2004-2005)
1250Ignition relay/Starter relay
1340Trailer tow battery. Trailer tow turn signals
1410Daytime Running Lamps (DRL) (Canada), Foglamps (2001-2002; export only)
1515Memory (KAPWR) (2001-2002), Memory (PCM/DEATC/Cluster) (2003-2005), Courtesy lamps (2003-2005)
1615Headlamp switch (2001-2003), Foglamp switch (2003), Park lamps (2004-2005), Autolamp parklamps (2004-2005), Front foglamps relay coil (2004-2005)
17204x4 (v-batt 2) (2001-2003)
5Two-speed 4x4 (relay coils) (2004-2005)
18204x4 (v-batt 1) (2001-2003), PCM with two-speed 4x4 clutch (2004-2005)
1920High beam relay
2030Trailer electric brake module
2130Front wiper motor
2220Autolamp; Low beam
2330Ignition switch, PCM diode (2004-2005)
2420Rear fog lamps (2001-2002; export only)
2515Brake on-off (2004-2005)
2615Fuel pump (2001-2003)
20Fuel pump (2004-2005)
2720Trailer tow lamps, Trailer tow back-up
2820Horn relay
3020Rear wiper motor
31Not used
32Not used
3330Auxiliary blower motor
3430Power seats, Adjustable pedals
3520Rear power point (2001-2002)
3640Blower motor
3715A/C clutch relay/Transmission
3815Coil on plug (2001-2003), HEGO (2004-2005), VMV (2004-2005), CMS (2004-2005), ESM (2004-2005), CVS (2004-2005)
3915Injectors/Fuel pump relay
4015PTEC power (2001-2003), PCM power (2004-2005)
4115HEGO (2001-2003), VMV (2001-2003), CMS (2001-2003), PTEC (2001-2003), Coil on plug (2004-2005; 4.6L engine only), Ignition coil (2004-2005; 4.0L engine only)
4210Right low beam
4310Left low beam
4415Front foglamps
455Brake pressure switch (2001-2002)
2Brake pressure switch (ABS) (2003-2005)
4620High beams
6230Circuit Breaker: Delayed accessory (2001-2002), Power windows circuit breaker (2003-2005)
47Horn relay
48Fuel pump relay
49High beam relay
50Fog lamp relay
51Police IVD relay
DRL relay (Canada)
52A/C clutch relay
53Trailer tow right turn
54Trailer tow left turn
55Blower motor relay
56Starter relay
57PTEC relay
PCM relay
58Ignition relay
59Driver brake applied or DRL relay (Canada only)
60PCM diode
61A/C clutch diode

Rear Relay Box

The relay box is located on the rear passenger side quarter trim panel.


№Circuits Protected
14Not used
15Trailer tow back- up lamps
16Not used
17Not used
18Not used
19Trailer tow park lamps
20Trailer tow battery charge
21Not used
22Approach lamps
23Not used
3Not used
4Not used
Auxiliary Relay Box

The relay box is located on the front right fender well underneath the speed control module (Canadian vehicles equipped with AdvanceTrac).



This website uses cookies to improve your experience. We"ll assume you"re ok with this, but you can opt-out if you wish. Cookie settingsACCEPT
Privacy & Cookies Policy

Privacy Overview
This website uses cookies to improve your experience while you navigate through the website. Out of these cookies, the cookies that are categorized as necessary are stored on your browser as they are essential for the working of basic functionalities of the website. We also use third-party cookies that help us analyze and understand how you use this website. These cookies will be stored in your browser only with your consent. You also have the option to opt-out of these cookies. But opting out of some of these cookies may have an effect on your browsing experience.
Necessary cookies are absolutely essential for the website to function properly. This category only includes cookies that ensures basic functionalities and security features of the website. These cookies do not store any personal information.

See more: What Does Jessica Mean In English, Name Jessica Meaning, Origin Etc

Any cookies that may not be particularly necessary for the website to function and is used specifically to collect user personal data via analytics, ads, other embedded contents are termed as non-necessary cookies. It is mandatory to procure user consent prior to running these cookies on your website.